IVG XL 35K Prefilled Pod Kit

Legal. The June 2025 ban took out single-use disposables, not big-puff devices that recharge and refill, and the XL 35K is firmly the latter. The battery tops up over USB-C and the pod swaps out, and the prefilled pod itself is 2ml (the larger 22ml supply sits across two separate refill containers), so it sits inside TPD rules.

In other words, a 35,000-puff figure does not make it a banned disposable; what matters is that it is rechargeable and the pod is replaceable, which it is. It lives in our big-puff vapes range as a proper post-ban device, just one built for an unusually long run between buys.

Inside the pod sits a 1.1ohm dual mesh coil, which is what gives the XL 35K its clean, even flavour and a tight mouth-to-lung draw, the familiar pull of a cigarette rather than a big airy lungful. Every pod is prefilled with IVG's 20mg (2%) nic salt, the UK legal maximum and the strength most people use coming off cigarettes.

There is no liquid to handle and nothing to refill by hand. When a pod runs dry you swap in a fresh XL 35K pod, which comes as the same 2ml pod plus two 10ml refills. The pods are specific to the XL 35K, so they will not fit the Pro 12 or other IVG kits.

First run takes a moment, with no filling or priming to do.

Low per puff, which is the point of buying this much capacity. The kit is about £9.60 in our box of five, and each ships with a full 22ml pod set ready to go. After that you only buy refills: a pack of XL 35K pods gives another 22ml and up to 35,000 puffs for less than a fresh kit, because you keep the battery and screen.

Spread 35,000 puffs across the price of a pod and the per-puff cost is tiny, well under what a run of disposables or even smaller 10K kits work out at. The catch is the bigger upfront outlay than a cheap bar, but if you vape steadily it pays back fast, and there is far less packaging in the bin than buying device after device.

Three IVG rechargeables at very different scales. The XL 35K is the long-haul one. Quick version:

Most XL 35K niggles are one of a few simple things. Worth a run-through before assuming it is faulty.

If you want the longest run between buys, yes. 35,000 puffs is a huge amount of vaping from one device, and because you recharge it and only ever replace the pod, the cost per puff lands well below a string of disposables. At 5 kits for £47.99 that is about £9.60 a kit before you even factor in the refills.

The trade is the upfront step over a cheap disposable, and you do have to keep it charged and buy pods. If you would rather a smaller, simpler device, IVG's Pro 12 does 10,000 puffs for less outlay. For sheer longevity though, the XL 35K is the one.